QUESTIONS RELATING TO MODEL HGR 360 ELECTRIC  GOLF CART WITH FULL REMOTE CONTROL

DESIGN

Q Why is this a better design than previous trolleys that Kolnex has been selling selling now for the past 3 years?

A This is not a "better" design - it is a "different" frame design. This cart frame was designed by Pacific Rim Golf Corp. with two things in mind. Firstly to make a very strong and robust frame - secondly to reduce the weight of the cart. This new frame is now also stronger and very attractive.

FRAME

Q What is the frame of the cart made of?

A All major components are of aluminum

Q Are there any improvements in the new design of this frame?

A Yes. This newly designed frame is a "mono-tube" - oval shaped frame. The wheelbase has been reduced from 28" to 23". The front wheel and bag support redesigned - now more robust with one piece wheel housings.

WEATHERPOOF

Q Is the cart weatherproof?

A Yes. It is designed specifically for use by golfers in all weathers. All electronic parts, switches, motors, and gearboxes are sealed.

SPEED CONTROL

Q Will I also have manual control over the forward speed of the cart?

A Yes. Just set the speed using the high quality rheostat control knob at the handle - any speed from very slow up to about 4.5 MPH

REMOTE CONTROL

Q What can I control from the remote control transmitter?

A You can control direction - forward - reverse - left - right. Speed - faster - speed slower. Stop. This brand new remote control transmitter has been designed from scratch and is the most sophisticated remote control available.

Q Is it difficult to "key-in" this transmitter to the golf trolley computer controller?

A No. A replacement transmitter can now be easily "keyed" to the trolley computer controller by just holding it near the trolley and pressing a combination of buttons.

WHEELS

Q What type of wheels?

A The wheels are made from high-impact solid plastic - with the addition of a special rubberized treads to provide extra grip onto the fairway grass (see image). Wheels are 28” apart for superior side-hill stability.

TURF PRESSURE

Q How much weight is transferred onto the fairway grass?

A These are “turf-friendly” wheels, with wide tires to protect the turf. These carts have a ground pressure of less than 3 psi.

ELECTRIC MOTORS & GEARBOXES

Q What type of electric motor is used on this trolley?

A The motor and gearbox assembly on this trolley is the most superior motor/gearbox assembly available anywhere in the world today. Made by the LINIX corporation these highly upgraded assemblies are guaranteed for longevity - unlike previous motors designed to operate for just 400 to 600 hours.

POWER TRAIN

Q What type of power train is used?

A A completely new design! The 180 Watt LINIX motor drives through a horizontally opposed matched gearbox - via the axle - through a specially designed positive drive-coupling (no more drive pins).

Q Will I be able to push the cart in the event of a total power failure?

A Yes. Just release the small catch on each drive-wheel - move wheel outwards slightly to the free-wheel notch on the axle. Takes seconds.

ASSEMBLY

Q Is it difficult to assemble?

A Out of the box there is no assembly necessary - unlike the LX400 model, the front wheel assembly on the HGS180 is already fitted to the frame.

USABLE DISTANCE

Q   For how long will the cart run?

A   The expected usable range of this cart will depend upon the elevations of the course and the current condition of the battery - under normal conditions this will be always be up to 27-holes for most of the life of the battery.

BATTERY

Q   What type of battery?

A    Now fitted with an upgraded "High-Cycle" 12 volt 20 Ampere/Hour "maintenance-free" - non-spillable battery

Q    How long will it last?

A    Longevity is dependant upon many factors, so will not always be the same. The "High Cycle" battery will however provide longer life and more charges than regular batteries.

Q    What should I do with the battery when not in use?

A    Immediately after use connect the battery to the charger and charge it completely - usually at least overnight. Unlike the charging arrangements for some other golf caddies, the battery can then be disconnected from the charger, and stored if not being used - for instance if not playing golf during the winter. There will however be a slow power loss, so it is important to recharge the battery every 2 to 3 months.

CHARGER

Q Do I have to remember to check on the battery condition and disconnect from the charger?

A   No. This is completely automatic. The charger is a special 3-stage "intelligent" charger which monitors and controls the electrical input to the battery. The battery should be charged after each round of golf. Simply lift out the battery and stand next to the charger – connect them using the small polarized plug. After use  the battery should always be placed on charge in between rounds - even if up to several weeks - the battery should then always be in good condition.

Q   What is the operating voltage of the charger?

A   Dual voltage. 110/240 volt input - 3 Amp output. Suitable for the US and European markets.

SALES TAX

Q  Will I have to pay sales tax?

A  Sales tax at the rate of 7.75% is applicable only to orders with a delivery address in California - all other order are exempt from sales tax.

WARRANTY

Q  What warranty covers the carts?

A  A one-year warranty covers all parts of the cart with the exception of the battery which is covered with a limited warranty for a period of three months. See Terms of Sale and Warranty